Start your EVOTECH request in under a minute.
Keypad Door Access Installation & Repair in Katy, TX 77492
Many keypad-door calls around Katy are not about a bare door. They are about a door that already has a keypad and has stopped behaving: it beeps green and stays shut, it unlocks on its own, or it died after a thunderstorm. This page is the diagnostic side of the trade, covering how to read the symptom, what usually causes it and when repairing the original install beats replacing it.
Read the symptom first: a field guide to misbehaving keypad doors
A keypad door has a short list of ways to fail, and each one leaves a recognizable fingerprint. Matching what you see to the likely cause saves a wasted visit and, often, an unnecessary new keypad.
| What you notice | Usual cause | First thing we check |
|---|---|---|
| Keypad flashes green, door stays locked | Strike bound by side pressure, or the lock is starved of voltage | Voltage at the lock while energized; how hard the door presses on the keeper |
| Door unlocks by itself or never relocks | Welded relay contacts, keypad set to toggle mode, or an exit sensor seeing motion | Relay state with power off; exit sensor aim and hold time |
| Keypad dark after a storm | Surge on an outdoor or long cable run | Supply fuse, keypad input stage, surge protection and grounding |
| Door swings open during a power cut | Fail-safe hardware installed on an outside door | Model label on the strike or lock; standby battery condition |
| Code works but the door will not relatch | Closer latch speed, sagging hinges or a shifted keeper | Closer valves, hinge screws, strike position |
| Certain buttons stop responding | Water behind the keypad face or sun damage | Gasket, mounting orientation, exposure |
| Codes work only some of the time | Loose data conductors or an unshielded run beside power | Terminations, cable type, shield drain |
| Backup battery swollen or flat | Battery past its service life, often in a hot closet or attic | Date written on the battery; enclosure temperature |
Two of those rows account for most of our service calls, so they get their own explanation below.
Why a keypad can say yes while the door says no
Preload: the door is leaning on the lock
An electric strike releases by letting its keeper swing out of the way of the latch. If the door is pressed hard against that keeper by new weatherstrip, a warped slab, a closer set too strong or wind load on an outswinging door, the solenoid cannot pull its mechanism free. The telltale test is simple: enter the code while someone pushes the door slightly inward. If it releases, the electronics are fine and the problem is mechanical. The fix is adjusting the door stop or seals, correcting hinge sag, or swapping in a strike built to release under preload.
Voltage drop: the wire is too thin for the distance
Lock power travels out and back, so a long run doubles against you. Take a strike drawing about half an amp at 12 volts, fed through 150 feet of 22 AWG conductor: that is roughly 300 feet of thin copper at around 16 ohms per thousand feet, close to five ohms in total, and it can drop well over two volts before the strike sees anything. The same run in 18 AWG loses about one volt. A strike running several volts short may click on a calm day and fail the moment anything leans on the door. We measure at the lock terminals while it is energized, never only at the supply.
Other electrical culprits
Many strikes are dual voltage and set by a jumper or by automatic sensing; one left on 24 volts while fed 12 releases weakly or not at all. A strike that hums loudly is being fed AC, which some models accept and DC-only models do not. And a supply that looks fine unloaded can sag badly under load if its battery has failed.
Warehouses, workshops and gates on Katy’s western edge
Beyond the subdivisions, the Katy area has a lot of flex space, warehouses and light industrial buildings along the I-10 corridor, and acreage properties with detached shops and gated driveways out toward Brookshire and Fulshear. Keypads on these properties fail for reasons an office door never sees.
- Tilt-wall and metal buildings. Man doors beside the loading docks are usually steel in hollow metal frames. Roll-up doors cannot take a keypad strike at all, so access is controlled at the adjacent personnel door or through the door operator’s own inputs.
- Afternoon sun. A keypad on a west-facing metal wall can run far hotter than the air temperature. Check the keypad’s rated operating range, and add a hood or move it to shade where possible.
- Long outdoor runs. A keypad on a gooseneck post at a driveway gate may be hundreds of feet from its controller. Those runs belong in conduit, use cable rated for the environment, and need surge protection at both ends with a proper ground. Without it, one nearby lightning strike can take out the keypad, the controller and the gate board together.
- Solar-powered gates. Many rural gate operators live on a solar panel and a battery. A backlit keypad draws power all night, every night, and can drain a marginal system during a cloudy week. Low-draw keypads, or wireless keypads with their own batteries, avoid that.
- Long outages. The 2024 storm season left parts of the Houston area without power for days. A system that fails secure with a mechanical key override, plus a standby battery sized for real runtime, keeps a warehouse both locked and usable.
Retrofit or replace: deciding what to do with an existing keypad door
Not every failing system needs to be torn out. If the strike, the cable and the power supply are sound, fixing the actual fault is the honest answer. We recommend going further only when the design itself is the problem:
- Everyone shares one code. When someone leaves, the only way to lock them out is to change the code for everyone else.
- There is no history. After a theft, nobody can say whose code was used or at what hour.
- The relay is outside. A standalone keypad with its release contacts on the public side can be bypassed by removing it from the wall.
- Several doors, several keypads. Each has its own code list to maintain by hand.
A retrofit usually keeps the lock hardware and the wire that tested good, and replaces the standalone keypad with a keypad or reader that reports to a controller on the secure side. That adds per-person codes, schedules and an entry log, and it can bring in cards, fobs or phone credentials later. Existing cable is only reused after a continuity and insulation check; a corroded splice in an outdoor box will undo any upgrade.
What happens on a troubleshooting visit, and what it costs to fix
- We ask when the problem started, what the weather was doing, and whether anyone recently worked on the door, the closer or the alarm.
- We operate the door exactly as your staff does, from both sides, watching the latch and keeper through a full cycle.
- We measure supply voltage unloaded, then at the lock terminals while the lock is energized.
- We take the pressure off the door by hand and try the code again to separate mechanical binding from electrical weakness.
- We inspect the relay, any suppression diode, fuses and the date on the standby battery.
- We test the exit sensor, any push-to-exit button and the door position switch.
- For gates and outbuildings, we check the outdoor cable, the surge protection and the ground connection.
- We explain the finding in plain language and give you options: repair it now, retrofit the weak part, or replace, with an itemized quote for whichever you choose.
If the system was installed by someone else, that is fine. We will work on it, and we will tell you plainly if anything we find is unsafe or does not provide free exit.
What decides the cost of a fix or an upgrade
A preload problem solved with a stop adjustment is a small job. A failed strike behind a grouted hollow metal frame, or a gate keypad whose buried cable was never in conduit, is a large one. In between, the price mostly depends on whether the existing wire can be reused, whether the power supply and battery need replacing, how far the keypad is from the secure side, whether you stay standalone or move to a controller, and how many doors are involved. Storm-damaged systems add the question of how much was hit: sometimes only a fuse and a keypad, sometimes the controller and the gate operator board as well. We price each piece separately so you can see where the money goes.
Keeping a repaired door from failing again
- Check the closer each season; Katy’s heat and humidity change how doors hang, and a closer that latched in March may stop short in August.
- Replace sealed standby batteries on a schedule every few years, sooner if the supply lives in a hot room, and write the install date on each battery.
- Twice a year, unplug the supply and confirm the door behaves the way it is supposed to without power.
- Delete codes for people who have left, on a set routine rather than when someone remembers.
- Keep the master or admin code in a safe place, never written on the keypad cabinet.
Related services
Frequently asked questions
The keypad beeps, but the door only opens if someone pushes on it. Why?
Can you work on a keypad system someone else installed?
Can a gate keypad run from a solar-powered gate opener?
Why does our door unlock by itself at night?
How do we remove a former employee’s code?
Get your keypad door working properly again
Describe the symptom, the door and whether it is a building entrance, a shop or a gate. We will diagnose it on site and send an itemized quote for the repair or upgrade. Call (832) 359-2425. EVOTECH IT LLC is a licensed and insured low-voltage contractor with more than 20 years in the Katy area.
Book an On-Site Estimate
Ready for EVOTECH to help?
Before you leave, send the quick version. We will review the page you came from and reply with the clean next step.
